Gas generator sets have high requirements for operating environment and supporting equipment. Huaquan Power reminds that when using generator sets, in addition to complying with the following regulations, operating procedures should be formulated based on specific circumstances and strictly followed. Let's take a look at what precautions should be taken when using gas generator sets!

一、机房设置要合理

1、 The setting of the computer room should be reasonable

1、燃气发电机组机房一般采用敞开式或半敞开式，地面要平整易清理。

1. The gas generator room generally adopts an open or semi open type, and the ground should be flat and easy to clean.

2、封闭式机房，应按防爆要求设计，须是单层建筑，门窗一律外开，设置大流量排风装置，减少可燃气体积聚等。

2. The enclosed computer room should be designed according to explosion-proof requirements, and must be a single-story building with all doors and windows open outwards. A large flow exhaust device should be installed to reduce the accumulation of combustible gas volume.

3、机房与操作间应隔开，观察窗口应用双层玻璃，且有钢丝网防护。

3. The computer room and the operation room should be separated, and the observation window should be double glazed and protected by steel wire mesh.

4、机房应设有避雷装置。

4. The computer room should be equipped with lightning protection devices.

5、燃气发电机组运行现场不得有明火，需有&濒诲辩耻辞;严禁烟火&谤诲辩耻辞;等警示标志。

5. There must be no open flames on the operation site of the gas generator set, and warning signs such as "No Smoking or Fireworks" must be displayed.

6、配备足的灭火器材。

6. Equipped with sufficient firefighting equipment.

7、发动机排气系统的废气中，混有可燃气体，要设计并安装由发动机引向室外的排气管系。

7. The exhaust gas from the engine exhaust system is mixed with combustible gases, and an exhaust pipe system led from the engine to the outdoor should be designed and installed.

二、燃气发电机组及配套设备要达标

2、 Gas generator units and supporting equipment must meet the standards

1、燃气发电机组机房内的电气设施应为防爆型，维修时要切断电源。

1. The electrical facilities in the gas generator room should be explosion-proof and the power supply should be cut off during maintenance.

2、设置紧急阀门，以备厂房内发生紧急情况时，可切断气源，此阀门应离操作间较近。

2. Set up emergency valves to cut off the air supply in case of an emergency in the factory building. This valve should be close to the operating room.

3、燃气发电机组机房内要安置燃气浓度报警器。

3. A gas concentration alarm should be installed in the gas generator room.

叁、燃气管道要达标并及时检修

3、 Gas pipelines must meet standards and be promptly repaired

1、燃气管道应采用管壁较厚的钢管，接头处要密封要好。

1. Gas pipelines should use thick steel pipes with good sealing at the joints.

2、定期检查阀门，发现问题要及时维修或更换。

2. Regularly inspect valves and promptly repair or replace any problems found.

3、燃气管线上的胶管应定期换，禁用老化胶管。

3. The rubber hoses on the gas pipeline should be replaced regularly and aged rubber hoses should be prohibited.

4、对燃气发电机组及燃气管线进行检修时，须切断燃气来源并将内燃气排净，未查明事故原因和采取相应措施前，不得向燃气设施恢复送气。进行维护检修时，应采取防爆措施或使用防爆工具，严禁用铁器等工具进行敲击作业。

4. When repairing the gas generator unit and gas pipeline, the gas source must be cut off and the internal gas must be completely discharged. Before identifying the cause of the accident and taking corresponding measures, gas supply to the gas facilities must not be restored. When carrying out maintenance and repair, explosion-proof measures should be taken or explosion-proof tools should be used. It is strictly prohibited to use tools such as iron tools for knocking operations.

本文由燃气发电机组友情奉献.更多有关的知识点击:我们将用真诚的态度.为您提供为全面的服务.更多有关的知识我们将会陆续向大家奉献.敬请期待.

This article is dedicated to the friendship of gas generator units. For more relevant knowledge, click on: We will provide you with comprehensive services with a sincere attitude. We will gradually contribute more relevant knowledge to everyone. Stay tuned