官方二维码
当前位置：
2023.09.20
静音型发电机在安装调试时要注意什么？
首先合上发电机的控制箱内的保险箱后，然后按下启动按钮。如果出现启动不成功时，等待一定时间后，再次按下启动键。
First, close the safety box in the control box of the generator, and then press the start button. If the startup fails, wait for a certain amount of time before pressing the start button again.
启动发电机时应该对发电机的邮箱压力进行观察，如果油压没有显示很指数低时，应立即停止并检查。
When starting the generator, the pressure in the generator's mailbox should be observed. If the oil pressure does not show a very low index, it should be immediately stopped and checked.
大功率静音型发电机启动后，控制箱的各项参数进行检查。包括：机油压力水温电压频率。
After starting the high-power silent generator, check the various parameters of the control box. Including: oil pressure, water temperature, voltage frequency.
通常情况下，机组启动后转速直接达到额定转速；怠速时间不易过长，一般为3词5尘颈苍。否则会对发电机的相关元器件烧坏，导致无法使用。
Usually, after the unit starts, the speed directly reaches the rated speed; The idle time is not easy to be too long, usually 3-5 minutes. Otherwise, it will burn out the relevant components of the generator, causing it to be unusable.
检查机组油路水路及电器的是否出现渗漏情况；
Check if there is any leakage in the oil, water, and electrical circuits of the unit;
检查发电机机组各连接处的紧固情况，看有无松动和剧烈振动
Check the tightness of each connection of the generator unit for looseness and severe vibration
观察机组各种保护和监视装置是否正常；
Observe whether various protection and monitoring devices of the unit are normal;
当转速达到额定转速，起空载运行的各项参数稳定后，合闸送电
When the speed reaches the rated speed and all parameters for starting and no-load operation are stable, close the power supply
检查确认控制屏各项参数是否在允许的范围内，再次检查机组的振动，有无叁漏及其它故障
Check and confirm whether the parameters of the control screen are within the allowable range, and recheck the vibration of the unit for any three leaks or other faults
柴油发电机运行时严禁超负荷
Overloading is strictly prohibited during the operation of diesel generators
认真填好柴油发电机调试表格，一式二份各自保存，与操作人员交代注意事项以及调试知识培训。
Carefully fill out the diesel generator debugging form, keep two copies each, and explain the precautions and debugging knowledge training to the operators.
感谢您的阅读，此文的文章来源：瓦斯发电机组更多的内容和问题请点击：我们会继续努力的为您提供服务，感谢您的支持！
Thank you for reading. The source of this article is: Gas Generator Set. For more information and questions, please click on: We will continue to work hard to provide you with services. Thank you for your support!
上一篇： 瓦斯发电机组为什么都是用低浓度？
下一篇：汽轮发电机组振动现场诊断